Product ID:FORMULA 724
MSDS Date:09/14/1993
FSC:6850
NIIN:01-418-1702
MSDS Number: BYRYL

Emergency Phone: 201-569-5340

Info Phone: 201-567-3000

Cage: 56883

Telephone: 201-567-3000

Cage: 56883

ALIPHATIC PETROLEUM HYDROCARBON

CAS: 64742-47-8

RTECS: OA5504000

Fraction By Weight: 100%

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION OF HIGH
CONCENTRATIONS OF VAPOR/MIST MAY CAUSE RESPIRATORY IRRITATION; CNS
EFFECTS. CONTACT MAY CAUSE SKIN AND EYE IRRITATION. ASPIRATION MAY
CAUSE LUNG INFLAMMATION AND/OR BRONCHITI S; GI TRACT IRRITATION.
CHRONIC: NONE SPECIFIED BY MANUFACTURER.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED-HEADACHE, DIZZINESS, ANESTHESIA,
DROWSINESS, UNCONSCIOUSNESS, OTHER CNS EFFECTS. EYES-SLIGHT
IRRITATION. SKIN-IRRITATION, DRYING. INGESTED-DIARRHEA, NAUSEA,
VOMITING.
Medical Cond Aggravated by Exposure:DERMATITIS.

First Aid:EYES-FLUSH WITH WATER FOR 15 MINUTES. GET IMMEDIATE MEDICAL
ATTN. SKIN-REMOVE CONTAMINATED CLOTHES. FLUSH WITH WATER. SEE
DOCTOR IF IRRITATION PERSISTS. INHALED-REMOVE TO FRESH AIR.
ADMINISTER OXYGEN OR ARTIFICIAL RESPIRATION AS NEEDED. GET
IMMEDIATE MEDICAL ATTENTION. INGESTED-DO NOT INDUCE VOMITING! CALL
A PHYSICIAN IMMEDIATELY. USE A STOMACH PUMP.

Flash Point Method:TCC
Flash Point:160F,71C
Lower Limits:0.6
Upper Limits:7.0
Extinguishing Media:WATER FOG, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
FULL PROTECTIVE GEAR. COOL FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:COMBUSTIBLE LIQUID. CAN FORM COMBUSTIBLE
MIXTURES AT OR ABOVE FLASH POINT. CONTAINERS CAN RUPTURE & EXPLODE
UNDER FIRE CONDITIONS DUE TO PRESSURE/VAPOR BUILDUP.

Spill Release Procedures:ELIMINATE ALL SOURCES OF IGNITION. USE
ABSORBENT MATERIAL AND PLACE IN A CONTAINER FOR DISPOSAL. KEEP OUT
OF SEWERS, WATERWAYS. IF ENTERS SEWER OR WATERWAY, NOTIFY NATIONAL
RESPONSE CENTER AT 800-424- 8802.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DO NOT STORE ABOVE 120F. KEEP AWAY
FROM SOURCES OF IGNITION AND STRONG OXIDIZING AGENTS.
Other Precautions:THIS PRODUCT CONTAINS NO REPORTABLE CERCLA MATERIALS.
SARA III (311/312)- ACUTE HEALTH, FIRE; 313-NONE. DOES NOT CONTAIN
ANY CAL PROP 65 CANCER/BIRTH DEFECTS/REPRODUCTIVE HARM.
PHOTOCHEMICALLY REACTIV E MATERIAL-NO; VOC-780 G/L, <2 MM HG.

Respiratory Protection:IF ENGINEERING CONTROLS FAIL OR NON-ROUTINE USE
OR AN EMERGENCY OCCURS; WEAR AN MSHA/NIOSH APPROVED RESPIRATOR OR
AN AIR-SUPPLIED RESPIRATOR OR SCBA, AS REQUIRED. USE IN ACCORDANCE
WITH 29 CFR 1910.13 4 AND MANUFACTURER'S RECOMMENDATIONS.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION OR LOCAL EXHAUST TO
MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:NITRILE, PVA.
Eye Protection:SAFETY GLASSES/CHEMICAL SPLASH GOGGLES.
Other Protective Equipment:RUBBER BOOTS, APRON, GAUNTLETS, OR RAIN GEAR
SHOULD BE WORN DEPENDING ON CONDITIONS. DLA-HMIS: EYE
WASH/EMERGENCY SHOWER
Work Hygienic Practices:WASH HANDS AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
ALL THE INGREDIENTS OF THIS PRODUCT ARE LISTED IN THE TSCA.

HCC:V4
Boiling Pt:B.P. Text:400F,204C
Vapor Pres:<2
Vapor Density:>5
Spec Gravity:0.78
Evaporation Rate & Reference:0.1(N-BUTYL ACETATE=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, WATER-WHITE LIQUID; MILD HYDROCARBON ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:SMOKE, FUMES, OXIDES OF CARBON.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL ENVIRONMENTAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.